(5)
(6)
(7)
(8)
(9)
(10)
(11)
TM 5-6115-628-14&P
Secure front step (14) to fender (22) with seven screws (19), 14 flat washers (20) and
seven nuts (21).
Insert screw (15) with flat washer (16) through handbrake bracket (8), front step (14)
and cross brace (31). Install Iockwasher (17) and nut (18) on screw from underneath
and tighten.
Insert two screws (5) with flat washers (6) through handbrake bracket (8) and trailer
frame (9). Install one nut (7) on each screw and tighten.
Insert two screws (10) through front step (14) and handbrake cable bracket (13). Install
one flat washer (11) and one nut (12) on each screw and tighten.
Position handbrake cable clevis (31) on handbrake lever mechanism (4). Insert clevis pin
(2) and secure with cotter pin (1).
NOTE
When installing roadside front step, omit steps (10) and (11).
Install accessory box (paragraph 4-19, b).
Install fuel can brackets (paragraph 4-18, b).
4-22.
Rear Steps Replacement. (See figure 4-9.) The roadside and curbside rear steps on both
trailers are symmetrical, and replacement procedures are the same for all.
a. Removal.
(1) Remove two screws (1, figure 4-9), two flat washers (2) and two nuts (3) securing rear
step bracket (4) and platform anchor (5) to trailer frame (6) under taillight (7).
(2) Remove two screws (8), four flat washers (9) and two nuts (10) securing rear step (11) to
trailer frame (6).
(3) Remove five screws (12), ten flat washers (13) and five nuts (14) securing rear step (11)
to fender (15). Remove rear step from trailer.
b. Installation.
(1) Position rear step (11) on trailer frame (6).
(2) Secure rear step (11) to trailer frame (6) with two screws (8), four flat washers (9) and
two nuts (10).
(3) Secure rear step (11) to fender (15) with five screws (12), ten flat washers (13) and five
nuts (14).
(4) Aline two mounting holes in rear step bracket (4) with holes in trailer frame (6) under
taillight (7) and insert two screws (1),
(5) Slide S-hook at chain end of platform anchor (5) onto threaded end of lower screw (1)
inside trailer frame (6).
4-21
