TB 9-6115-645-13
Section II. INSTALLATION INSTRUCTIONS
INSTRUCTIONS TO UNIT MAINTENANCE FOR INSTALLATION OF WINTERIZATION KIT ON
THE 60kW TACTICAL QUIET GENERATOR SET.
The following instructions have been provided so you can install, Heater Kit, 60KW Generator Set
National Stock Number: 6115-01-474-8344 on your Generator Set.
WARNING
Disconnect negative battery cable from left battery and the positive
battery cable from the right battery before doing the following
procedures. Failure to observe this warning could result in severe
personal injury or death.
WARNING
Before disconnecting any coolant lines, let generator cool from
operation, then relieve pressure by opening radiator cap carefully.
Coolant is hot, and under pressure, and may cause burns.
WARNING
Catch fuel in suitable container. Keep spilled fuel away from hot
engine and all fires, and wash with warm water after getting any on
skin. Fuel highly flammable and is irritating to skin.
WARNING
Battery acid can cause burns to unprotected skin. Wear protective
clothing including rubber gloves and eye protection when servicing the
batteries. Failure to observe this warning could result in severe injury
or death.
WARNING
Batteries give off a flammable gas. Do not smoke or use open flame
when performing maintenance. Flames and explosion could result in
severe personal injury or death.
5-4.1
INSTALLATION PROCEDURES.
INITIAL SETUP
Tools
Equipment Conditions
Tool Kit, General Mechanic's Reference
Tool Kit, Automotive Generator shut down
(Common No. I) TM 9-6115-645-10
TM 9-6115-645-24
TM 9-2815-256-24
