ARMY TM 9-6115-645-24
AIR FORCE TO 35C2-3-444-12
MARINE CORPS TM 09244A/09245A-24/2
2-87.2
a.
b.
c.
d.
e.
f.
2-87.3
a.
b.
c.
d.
e.
f.
g.
h.
Inspection.
Shut down generator set.
Remove fuel tank filler neck, paragraph 2-87.1.
Inspect hose (26, FIGURE 2-26) for cracking, wear, or other damage.
Inspect filler neck (23) for corrosion, cracking, or other damage.
Inspect filler neck cap and tube assembly (14) for damage.
Install fuel tank filler neck, paragraph 2-87.3.
Installation.
Position hose (26, FIGURE 2-26), damps (24) and (25), and filler neck (23) on fuel tank.
Install bolts (21) and nuts (22) securing filler neck (23) to generator set housing.
Tighten clamps (24) and (25).
Install fitting (18), washer (20), and nut (19) in side of filler neck (23).
Install adapter (17) on fitting (18) and connect hose (16) to adapter (17) with clamp (15).
Install filler neck cap and tube assembly (14).
Close fuel drain valve (29), install cap (27), and service fuel tank. Refer to TABLE 2-2 for proper fuel.
Connect negative battery cable. Close battery access door and engine access doors.
2-88 FUEL DRAIN VALVE.
2-88.1
a.
b.
c.
d.
e.
f.
g.
h.
2-88.2
a.
b.
c.
d.
e.
f.
g.
Removal.
Shut down generator set.
Open battery access door and disconnect negative battery cable.
Open left side engine access doors.
Remove cap and chain assembly (27, FIGURE 2-26) from adapter (28).
Diesel fuel is flammable and toxic to eye, skin, and respiratory tract. Skin/eye
protection required Avoid repeated/prolonged contact. Good general ventilation is
normally adequate.
Open drain valve (29) and drain fuel into suitable container.
Remove drain valve (29) and adapter (28) from elbow (30).
Remove adapter (28) from drain valve (29).
if necessary remove elbow (30) and adapter (31) from fuel tank fitting.
Installation.
If removed, install adapter (31, FIGURE 2-26) and elbow (30) in fuel tank fitting.
Install fuel drain valve (29) into elbow (30).
Install adapter (28) into drain valve (29), and cap and chain assembly (27) on adapter (28).
Ensure fuel drain valve (29) is closed and service fuel tank. Refer to TABLE 2-2 for proper fuel.
Check fuel drain valve and fittings for leakage.
Close left side engine access doors.
Connect negative battery cable and dose battery access door.
2-123
