ARMY TM 9-6115-645-24
AIR FORCE TO 35C2-3-444-12
MARINE CORPS TM 09244A/09245A-24/2
2-86.3
a.
b.
c.
d.
e.
f.
g.
h.
i.
2-86.4
a.
b.
c.
d.
e.
f.
g.
h.
i.
Removal.
Shut down generator set.
Open battery access door and disconnect negative battery cable.
Open left side engine access doors.
Tag and disconnect auxiliary fuel pump (8, FIGURE 2-26) electrical connector.
Loosen damps (la). Disconnect filter (10) and remove adapter fitting (1b) from filler neck panel fitting (12).
Remove adapter fitting (1b) from fuel inlet hose (1). Remove filter (10) from auxiliary fuel pump (8). Cap fuel
inlet hose (1).
Disconnect auxiliary fuel outlet line (2) from auxiliary fuel pump (8).
Remove nuts (3), Iockwashers (4), bolts (5), washers (6), cap and chain assembly (7), and auxiliary fuel pump (8).
Remove fitting (9) from auxiliary fuel pump.
If necessary, remove nut (11) and fitting(12) from fuel filler panel.
Installation.
If removed, install fitting (12, FIGURE 2-26) and nut (11) in fuel filler panel.
Install fitting (9) to auxiliary fuel pump (8).
Install auxiliary fuel pump (8) and cap and chain assembly (7) in generator set with bolts (5), washers (6), lock-
washers (4), and nuts (3).
Connect auxiliary fuel outlet line (2) to auxiliary fuel pump (8).
Remove caps from fuel inlet hoses (1). Install filter (10) on auxilary fuel pump (8). Install adapter (1b) on fuel
inlet hose (1) and connect adapter fitting (1b) to filler neck panel fitting (12). Connect other end of fuel inlet
hose to filter (10). Tightnen damps (1a).
Connect auxiliary fuel pump electrical connector and remove tag.
Connect negative battery cable. Close battery access door.
Move generator set MASTER SWITCH to PRIME AND RUN AUX FUEL position and check for fuel leaks.
Return MASTER SWITCH to OFF position and close engine access doors.
2-87 FUEL TANK FILLER NECK.
2-87.1
a.
b.
c.
d.
e.
f.
g.
h.
i.
j.
2-122
Removal.
Shut down generator set.
Open battery access door and disconnect negative battery cable.
WARNING
Diesel fuel Is flammable and toxic to eyes, skin, and respiratory tract. Skin/eye
protection required. Avoid repeated/prolonged contact. Good general ventilation
is normally adequate.
Remove cap (27, FIGURE 2-26), open fuel drain valve (29) and drain fuel into suitable container.
Open left side engine access doors.
Remove filler neck cap and tube assembly (14).
Loosen damp (15) and disconnect hose (16) from adapter (17).
Remove adapter (17) from fitting (18).
Remove nut (19), washer (20), and fitting (18) from side of filler neck (23).
Remove bolts (21 ) and nuts (22) securing filler neck (23) to generator set housing.
Remove damps (24) and (25), hose (26), and filler neck (23) from fuel tank opening. Cover fuel tank opening.
Change 1
