ARMY TM 9-6115-641-24
AIR FORCE TO 35C2-3-456-12
2-82-1. Removal. - Continued.
a.
Shut down generator set.
b. Open left side engine access door and disconnect negative battery cable.
Diesel fuel is flammable and toxic to eyes, skin, and respiratory tract. Skin/eye
protection required. Avoid repeated/prolonged contact. Good general ventilation
is normally adequate.
c.
Remove cap (28, Figure 2-21), open fuel drain valve (29) and drain all fuel into suitable container.
d.
Remove fuel drain valve (29) from fitting (30) at left side skid.
e.
Remove fuel drain line (31) from adapter (40) and fitting (30).
f.
Remove nut (32) and fitting (30) from left side skid.
2-82-2. Installation.
a.
Install fitting (30, Figure 2-21) in left side skid with nut (32).
b.
Install fuel drain line (31) to fitting (30) and adapter (39).
c.
Install fuel drain valve (29) in fitting (30) at left side skid.
d.
Install cap (28) on valve (29). Ensure fuel drain valve (29) is closed.
e.
Fill fuel tank with fuel. See Table 2-2 for recommended fuel. Check for fuel leaks.
f.
Connect negative battery cable and close access door.
2-83.
FUEL TANK.
2-83-1. Removal.
a.
Shut down generator set.
b.
Open left side engine access door and disconnect negative battery cable.
Diesel fuel is flammable and toxic to eyes, skin, and respiratory tract. Skin/eye
protection required. Avoid repeated/prolonged contact. Good general ventilation
is normally adequate.
c.
Drain fuel into a suitable tank container.
d. Remove front housing section, paragraph 2-19-1.
e.
Remove fuel tank drain valve, paragraph 2-82-1.
f.
Remove fuel tank (33, Figure 2-21) from generator set.
g. Remove fittings (34) and (35) from fuel tank fitting (36).
h.
Remove adapter (39) from fuel tank fitting (40).
i.
Remove fittings (36) and (40), washers (37) and (41), and bushings (38) and (42) from fuel tank (33).
j.
Remove fuel float switch, paragraph 2-77-2, fuel level sender, paragraph 2-76-2, and fuel pickup, paragraph
2-78-1 from fuel tank (33).
2-115
