ARMY TM 9-6115-671-14 AIR FORCE TO 35C2-3-446-32 MARINE CORPS TM 09249A/09246A-14 3-18 SECTION III. OPERATOR MAINTENANCE PROCEDURES __________ WARNINGBatteries give off a flammable gas. Do not smoke or use open flame when performing maintenance. Failure to comply can cause injury or death to personnel and equipment damage due to flames and explosion. __________ WARNINGBattery acid can cause burns to unprotected skin. Wear protective gloves and safety goggles. Failure to comply can cause personal injury. 3.3 GENERATORSETINSPECTIONANDSERVICE. 3.3.1 Introduction.a. This section contains operator maintenance procedures. Deficiencies noted during inspection which are beyond the scope of operator level maintenance shall be reported to the next higher level of maintenance. b. Refer to Table 3-4 for Quick Reference General Inspection. 3.3.2 BatteriesBT1andBT2. __________ WARNINGDC voltage is present at generator set electrical components even with generator set shut down. Avoid grounding yourself when in contact with any electrical components. Failure to comply can cause injury or death to personnel. a. Inspection. (1) Shut down generator set, paragraph 2.11.2. (2) Open BATTERY ACCESS door at front of generator set (Figure 1-2). (3) Inspect for damaged battery case, corrosion, or damaged and loose connections on terminal cable. __________ WARNINGBatteries give off a flammable gas. Do not smoke or use open flame when performing maintenance. Failure to comply can cause injury or death to personnel and equipment damage due to flames and explosion.NOTE Batteries used in the generator sets may be the maintenance-free type or the type that contains electrolyte. If the batteries in your generator set are maintenance free, skip steps (4) through (7), and go to step (8).
Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business
