ARMY TM 9-6115-643-10
AIR FORCE TO 35C2-3-445-21
1-7.7 Air Cleaner Assembly
contains controls and
(12). The air cleaner assembly
instruments for operating the
is located on the left side
engine and the generator.
behind the air cleaner access
door. It consists of a dry-
1-7.12 Malfunction Indicator
Panel (1) . The malfunction
type, disposable paper element
and canister. The air cleaner
indicator panel is located to
assembly features a dust
the left of the control panel
It indicates
collector which traps large dust
assembly.
particles. The air cleaner
malfunctions of the generator
assembly has a restriction
set components.
indicator which will indicate
when the air cleaner element
1-7.13 NATO Slave Receptacle
requires servicing.
(21). The NATO slave receptacle
is located on the left side of
1-7.8 Fuel Tank (17) . The fuel
the generator set under engine
tank is located below the engine
compartment access door. It is
and between the skid base side
used for slave starting.
members. The fuel tank has a
capacity of 14 gallons (53
1-7.14 Skid Base (4). The skid
liters) which will allow the
base supports the generator set.
generator set to operate for at
It has fork lift access openings
least 8 hours without refueling.
and cross members for short
distance movement. The skid
1-7.9 AC Generator (13) . The
base has provisions in the
AC generator is a single
bottom for installation of the
bearing, drip-proof,
generator set on a trailer.
synchronous, brushless, three
phase, fan-cooled generator.
1-7.15 Voltage Reconnection
The generator is coupled
Terminal Board (8). The voltage
directly to the rear of the
reconnection terminal board is
diesel engine.
located on the right side (rear)
of the generator set. The board
1-7.10 Load Output Terminal
allows reconfiguration from
Board (9) . The load output
120/208 to 240/416 VAC output.
terminal board is located on the
right side (rear) of the
1-7.16 Fuel Filter/Water
generator set. There are four
Separator (5). The fuel
output terminals located on the
filter/water separator is
board. They are marked Ll, L2,
located in the engine
L3 and LO. A fifth terminal,
compartment on the right side.
marked GND, is located next to
The element removes impurities
the output terminals and serves
and water from the diesel fuel.
as equipment ground for the
generator set. A removable,
1-7.17 Dipstick (15). The
solid copper bar is connected
dipstick is located in the
between the LO and GND
engine compartment on the left
terminals.
side. The dipstick shows the
lubricating oil level in the
1-7.11 Control Panel Assembly
engine crankcase.
(2). The generator set control
panel assembly is located at the
rear of the generator set and
