TM 9-6115-653-14&P
CHAPTER 2
OPERATING INSTRUCTIONS
Section I. OPERATING PROCEDURES
2-1.
Power Unit Operating Procedures. The typical mission for any mobile power generating equipment can be
described In three steps or phases. In the first phase, the power unit Is towed to the worksite and installed by unit level
technicians (paragraph 4-2). In the second phase of the mission, the operator starts the generator set, runs it to power a
system or equipment, and eventually shuts it down. In the final phase, the power unit is dismantled, packed up and
either moved to a new worksite or returned to standby status (paragraph 4-3). This final phase is also accomplished by
unit level technicians.
a.
Generator Set Operating Procedures.
WARNING
Do not operate power unit generator set until properly grounded (paragraph 4-2, b ) Serious
injury or death by electrocution can result from operating an ungrounded generator set.
Operating noise level of generator set can cause hearing damage. Ear protectors, as
recommended by medical or safety officer, must be worn when working near power unit.
CAUTION
To avoid damage to equipment, make certain of voltage, frequency, and phase
requirements of load connected to power unit.
NOTE
Before starting generator set, do your Before PMCS as described In table 3-2.
Detailed procedures for prestarting, starting, operating, and shutting down the power unit generator set is found in TM 5-
6115-464-12 and on the Operating Instruction data plate found on the equipment. Refer to the data plate, located inside
the right hand control panel door, to start and run the generator set Monitor and adjust power output as required during
operation At the end of the mission, shut down generator set in accordance with operating instructions on the data plate.
b.
Trailer Operating Procedures. Refer to TM 9-2330-205-14&P for specific operating procedures for the M200A1
trailer.
Section II. OPERATION OF AUXILIARY EQUIPMENT
2-2.
Operation of Auxiliary Equipment. There is no auxiliary equipment supplied with the power unit.
2-1
