ARMY TM 9-6115-643-24
AIR FORCE TO 35C2-3-445-22
Section Il. MAINTENANCE OF COOLANT SYSTEM
4.5
RADIATOR REPAIR.
Repair radiator in accordance with TM 750-254.
4.6
4.6.1
a.
b.
c.
d.
4.6.2
a.
b.
c.
d.
e.
f.
g.
h.
i.
j.
k.
l.
m.
n.
4.6.3
a.
b.
c.
Section Ill. MAINTENANCE OF FUEL SYSTEM
FUEL TANK.
Inspection.
Shut down generator set.
Remove fuel tank, paragraph 4.6.2.
Inspect fuel tank (6, FIGURE 4-2) for leaks, cracks, missing hardware, and other damage.
If no damage is found, install fuel tank, paragraph 4.6.3.
Removal.
Shut down generator set.
Open battery access door and disconnect negative battery cable.
Diesel fuel is flammable and toxic to eyes, skin, and respiratory tract.
Skin/eye protection required. Avoid repeated/prolonged contact. Good
general ventilation is normally adequate.
Drain fuel tank.
Remove engine and generator assembly, paragraph 3.6.1.
Remove fuel tank drain valve, paragraph 2.88.1.
Remove nuts (1, FIGURE 4-2), Iockwashers (2), washers (3), bolts (4), and plates (5) securing fuel tank to skid
base.
Remove fuel tank (6) from skid base.
Remove low fuel level/auxiliary fuel pump float switch, paragraph 2.90.2.
Remove fuel level sender, paragraph 2.89.2.
Remove fuel pickup, paragraph 2,91.1.
Remove fittings (7) from excess fuel studs (9) on right side of tank.
Remove fitting (8) from excess fuel stud (9) on left side of tank.
Remove studs (9), washers (10), and bushings(11) from fuel tank.
Cover all openings.
Remove covers placed over openings.
Install bushings (11, FIGURE 4-2), washers (10), and studs (9) in fuel tank (6).
Install fitting (8) in excess fuel stud (9) on left side of fuel tank.
4-12
