Section IV. UNIT PREVENTIVE MAINTENANCE CHECKS
AND SERVICES (PMCS)
Table 4-1 (Unit PMCS table) has been provided
so you can keep your equipment
in good operating
condition and ready for
its primary mission.
Warning, Cautions, and Notes. Always observe the WARNINGS, CAUTIONS, and NOTES appearing in your
PMCS table. Warnings and Cautions appear before applicable procedures. You must observe WARNINGS to prevent serious
injury to yourself and others. You must observe CAUTIONS to prevent your equipment from being damaged. You must
observe NOTES to ensure procedures are performed properly.
Explanation of Table Entries.
4-7.2.1 Item No. Column. Numbers in this column are for reference. When completing DA Form 2404 (Equipment
Inspection and Maintenance Worksheet), or DD Form 5988E (Equipment Inspection and Maintenance Worksheet), include
the item number for the checks/service indicating a fault. Item numbers also appear in the order that you must do checks and
services for the intervals listed.
4-7.2.2 Interval Column. This column tells you when you must do the procedure in the Procedure column. Perform
procedures such as Monthly or Quarterly at the listed calendar interval. Perform procedures designated by number of hours
when the equipment has been operated for that many hours.
4-7.2.3 Item to be Checked or Serviced Column. This column lists the item to be checked or serviced.
4-7.2.4 Procedure Column. This column gives the procedure for checking or servicing the item listed in the location, item
to check/service column. You must perform the procedure to know if the generator is ready or available for its intended
mission or operation. You must do the procedure at the time stated in the interval column.
4-7.2.5 Not Fully Mission Capable if: Column. Information in this column tells you what faults will keep your equipment
from being capable of performing its primary mission. If you make checks or services that show faults listed in this column,
do not operate the equipment.
4-7.2.6 Reporting and Correcting Deficiencies.
If Winterization Kit does not
perform as required, refer
to Chapter 4,
Section V. Troubleshooting.
Other Table Entries. Be sure to observe all special information and notes that appear in your table.
Special Instructions. Preventive maintenance is not limited to performing the checks and services listed in the
PMCS table. See Figure 4-1 for PMCS routing. Covering unused receptacles, stowing unused accessories, and other routine
procedures such as equipment inventory, cleaning components, and touch up painting are not listed in the table. If a routine
check is listed in the PMCS table, it is because experience has shown that problems may occur with this item. Take along
tools and cleaning cloths needed to perform the required checks and services.