ARMY TM 9-6115-671-14
AIR FORCE TO 35C2-3-446-32
MARINE CORPS TM 09249A/09246A-14
1-39/1-40 BLANK
1.17.15
Batteries (15). Two batteries are located at the front of the generator set. The batteries are
maintenance free, 12 volt type. After starting, the generator set is capable of operating with batteries
removed. A diode, located behind the control panel, protects the generator set if the batteries are
incorrectly connected.
1.17.16
Skid Base (16). The skid base supports the generator set. It has fork lift access openings and cross
members for short distance movement. The skid base has provisions in the bottom for installation of
the generator set on a trailer.
1.17.17
NATO SLAVE RECEPTACLE (17). The NATO SLAVE RECEPTACLE is located on the right side
(front) of the generator set. It is a NATO receptacle used for remote battery connection.
1.17.18
Water Pump (18). The water pump is located on the front of the engine. The pump circulates engine
coolant through the engine block and the radiator.
1.17.19
Oil Filter (19). The oil filter is located in the engine compartment on the left side. The filter removes
impurities from engine oil.
1.17.20
Engine (20). The generator is powered by a four cylinder, four cycle, fuel injected, turbocharged,
liquid-cooled diesel engine which occupies the front half of the generator set. The engine is also
equipped with a fuel filter/water separator, oil filter, and air cleaner assembly. Protection devices
automatically stop the engine during conditions of high coolant temperature, low oil pressure, no fuel,
overspeed, and overvoltage.
1.17.21
Battery Charging Alternator (21). The battery charging alternator is located on the right side of the
engine. It is capable of maintaining the batteries in a state of full charge in addition to providing the
required 24 VDC control power.
1.17.22
Dipstick (22). The dipstick is located in the engine compartment on the left side. The dipstick shows
the level of oil in the engine drain pan.
1.17.23
Starter (23). The starter is located on the left side of the engine. The electric cranking motor
mechanically engages the engine flywheel in order to start the diesel engine.
1.17.24
Crankcase Breather Filter Assembly (24). The crankcase breather filter assembly is located in the
engine compartment on the right side. The filter element removes oil particles and contaminants from
air as it passes from the crankcase to engine air intake.
1.17.25
Fuel Filter/Water Separator (25). The fuel filter/water separator is located in the engine compartment
on the right side. The element removes impurities and water from the diesel fuel.
1.17.26
Load Output Terminal Board (26). The load output terminal board is located on the right side (rear) of
the generator set. Four AC output terminals are located on the board. The are marked L1, L2, L3, and
L0. A fifth terminal, marked GND, is located next to the output terminals and serves as equipment
ground for the generator set. A removable, solid copper bar is connected between the L0 and GND
terminals.
1.17.27
Voltage Reconnection Terminal Board (27). The voltage reconnection terminal board is located on the
right side (rear) of the generator set. The board allows reconfiguration from 120/208 to 240/416 VAC
output.
